Sedigheh Yazdanpanah; Sara Mohammadi; Amir Hossein Elhami Rad
Abstract
Introduction: White tea is a new ingredient in a wide range of phenolic, antioxidant and antimicrobial compounds. The most important catechins in white tea are epicatechin, epigallocatechin, epicatechin- 3- galate, and epigallocatechin- 3- galate, which are flavonol gallates. The concentration of these ...
Read More
Introduction: White tea is a new ingredient in a wide range of phenolic, antioxidant and antimicrobial compounds. The most important catechins in white tea are epicatechin, epigallocatechin, epicatechin- 3- galate, and epigallocatechin- 3- galate, which are flavonol gallates. The concentration of these phenolic compounds in white tea is higher than green tea. Sesame seed oil, which is produced by cold pressing method, has a great ability to preserve antioxidant compounds. Significant oxidative stability of sesame oil is due to the presence of lignan non-soapy substances. Strong antioxidant compounds in sesame seed oil include sesamol, sesamulin (antioxidant precursor), sesaminol and its isomers. The aim of this study was to investigate the effect of natural antioxidants of sesame oil and white tea on inhibiting the effect of metals on oxidation of sesame oil. Materials and Methods: In this study, aqueous extract of white tea was extracted and sesame oil was produced using cold press. In the next step, six samples including control sample (sesame oil), sesame oil containing white tea extract, sesame oil containing white tea extract and 0.1 ppm iron, Sesame oil containing white tea extract and 0.1 ppm copper, sesame oil with tea and 0.1 ppm zinc extract and sesame oil containing 100 ppm BHT were prepared. In all samples, aqueous extract of white tea in the amount of 6 mg/ 10 g was added to sesame oil. Total phenol, antioxidant capacity, power reducing on white tea extract and antioxidant power, peroxide number, oxidation stability and fatty acids profile were measured. All experiments were performed in a completely randomized design with three replications and the means were compared with Duncan’s test at the level of (P<0.05). SAS V 9.1 software was used for statistical analysis of quantitative data. Results and Discussion: The results showed that the aqueous extract of white tea contained 4.06 (mg gallic acid per gram of sample) total phenol, 6.00 (μg/ ml) antioxidant capacity 0.020 (mg/ g). Ml) is a reducing power. The reducing power of BHT antioxidant was 40 times and the antioxidant power of BHT was 14.85 times more than the aqueous extract of white tea. In the inhibition of free radicals in sesame oil, the aqueous extract of white tea had a significantly greater effect than the control sample. The iron- containing sample had more oxidation than other samples. In the inhibition of free radicals in sesame oil, the aqueous extract of white tea had a significantly greater effect than the control sample. The iron- containing sample had more oxidation than other samples. Rancimat value for samples of control sesame oil, sesame oil with tea and iron extract, sesame oil with tea and copper extract, sesame oil with tea and zinc extract, sesame oil with tea extract and sesame oil with synthetic antuioxidant BHT respectively 8.79 4.80, 9.08, 9.35, 9.42 and 9.61 hours were measured. The highest stability was related to the sample of sesame oil and synthetic antioxidant BHT and the Results and Discussion: The results showed that the aqueous extract of white tea contained 4.06 (mg gallic acid per gram of sample) total phenol, 6.00 (μg/ ml) antioxidant capacity 0.020 (mg/ g). Ml) is a reducing power. The reducing power of BHT antioxidant was 40 times and the antioxidant power of BHT was 14.85 times more than the aqueous extract of white tea. In the inhibition of free radicals in sesame oil, the aqueous extract of white tea had a significantly greater effect than the control sample. The iron- containing sample had more oxidation than other samples. In the inhibition of free radicals in sesame oil, the aqueous extract of white tea had a significantly greater effect than the control sample. The iron- containing sample had more oxidation than other samples. Rancimat value for samples of control sesame oil, sesame oil with tea and iron extract, sesame oil with tea and copper extract, sesame oil with tea and zinc extract, sesame oil with tea extract and sesame oil with synthetic antuioxidant BHT respectively 8.79 4.80, 9.08, 9.35, 9.42 and 9.61 hours were measured. The highest stability was related to the sample of sesame oil and synthetic antioxidant BHT and the lowest stability was related to the sample of sesame oil with tea and iron extracts. In comparison with the effect of metals on the oxidation of sesame oil, the addition of iron to sesame oil has increased the oxidation rate compared to the two other examined metals (copper and zinc). Rare metals increase the oxidation rate of edible oils by increasing the production of free radicals from fatty acids or hydroperoxides. The composition of of fatty acids profile showed that palmitic acid, stearic acid, oleic acid, linoleic acid and linolenic acid were the predominant fatty acids in sesame oil. In the iron- containing sample, with increasing oxidation rate, the amount of linolenic acid decreased compared to other samples. The results of the Se index were confirmatory on the results of oxidative stability index. White tea extract and sesame oil due to their antioxidant and phenolic compounds have been able to inhibit free radicals and metal peroxidants, especially copper and zinc. Sesame oil extracted by cold pressing is not suitable for frying due to its low heat resistance, but it can be used in the formulation of salad dressings.
Food Technology
Reza Jaberi; Ahmad Pedram Nia; Sara Naji-Tabasi; Amir Hossein Elhami Rad; Masoud Shafafi
Abstract
Introduction: Fats are widely used in food formulations to improve nutrients and quality of food products. In recent years, consumer awareness of the relationship between diet and health has increased, which results in increasing concerns about fats in products, in terms of high levels of saturated fatty ...
Read More
Introduction: Fats are widely used in food formulations to improve nutrients and quality of food products. In recent years, consumer awareness of the relationship between diet and health has increased, which results in increasing concerns about fats in products, in terms of high levels of saturated fatty acids. Therefore, various attempts have been conducted to find appropriate method to produce solid fats with unsaturated fatty acid content. The production of low-fat cake is of special nutritional importance due to the effects of fats and the incidence of various diseases such as hypercholesterolemia and cardiovascular. In cake making, oil is very important, first of all, it has an effect on keeping the air in the cake dough. It causes porosity and increases the volume of the cake. The conversion of liquid oils to gel-like structures that have the properties of a solid fat (rheological properties, viscoelasticity, dispersibility, and softness) without using large amounts of saturated fats is an important development in the food industry, and structures produced by oleogelation are called oleogels. Therefore, the main purpose of this study was to produce low-calorie muffins by removing fat and replacing it with an oleogel system prepared from a soluble complex of xanthan gum and egg white by indirect foam molding. Materials and Methods: First, aerogels were produced indirectly using egg white protein complex and xanthan gum, and then oleogel was produced by adsorption of oil. In this method, first, water suspensions containing 0.5 wt% of xanthan and 5 wt% of egg white protein were prepared. In the next step, the oleogel was used to produce muffin with reduced oil in three levels of 10, 30 and 50%. In this study, texture characteristics, color, porosity, water activity, moisture, specific volume of muffin samples were investigated. In the control sample, cake dough contained 100% wheat flour, 50% sugar powder, 30% liquid vegetable oil, 2% baking powder, 0.2% vanilla, 36% eggs and 12% invert syrup. To prepare samples containing oleogels, oil was removed and different concentrations of oil reduction at the level of 50, 30 and 10% in the formulation were added to each treatment. Results and Discussion: Muffin with 10% reduced oil had the highest volume and density and had similar texture characteristics to the control sample. By reducing the amount of fat to 50% of the initial amount in muffin, the volume decreased and the firmness of the texture increased significantly (p <0.05). The reduction of the percentage of porosity confirmed that the texture stiffness in higher values of substitution. The sensory evaluation showed that the 10% reduced oil sample had the highest consumer acceptance. According to the results of this study, it can be suggested that preparing muffins with oleogels can reduce the problems caused by fats, while improved sensory and qualitative properties and be produced as a functional food.
Sahar Pakbaten; Mahdi Karimi; Amir Hossein Elhami Rad; Zahra Sheikholeslami
Abstract
The effect of sonication time (in three levels 0,2,4 min ) and mono- di glyceride (in three levels 0,0.3,0.6 %) on improving the quality of cupcake were studied. Color analyze (L*, a*,b*) for dough samples and specific volume, porosity shelf life, color analyze and texture of cake were done. Results ...
Read More
The effect of sonication time (in three levels 0,2,4 min ) and mono- di glyceride (in three levels 0,0.3,0.6 %) on improving the quality of cupcake were studied. Color analyze (L*, a*,b*) for dough samples and specific volume, porosity shelf life, color analyze and texture of cake were done. Results showed that increasing the levels of each factors (sonication and emulsifier) made a decrease in a*, b* of dough, crust and crumb of cake and increased in porosity, volume and L* of dough, crust and crumb color of cake. While these two factors used together changes were more obviously. In sample contain 0.6 % emulsifier that sonicated for 4 minute the highest decrease in a*, b* and increase in porosity, volume, shelf life and L* were observed.
Ana Abdolshahi; Seyed Ali Mortazavi; Ali Akbar Shabani; Amir Hossein Elhami Rad; Mehrdad Taheri; Mojtaba Heidari Majd
Abstract
Pistachio oil has important nutritional and therapeutic properties because of high concentration of essential fatty acids. The extraction method used to obtain natural compounds from raw matter is critical for product quality and especially protection of nutrition value of them. The study was conducted ...
Read More
Pistachio oil has important nutritional and therapeutic properties because of high concentration of essential fatty acids. The extraction method used to obtain natural compounds from raw matter is critical for product quality and especially protection of nutrition value of them. The study was conducted to compare fatty acid composition of pistachio oil extracted by two conventional procedures: soxhlet extraction (Sox) and maceration. Different solvents: n-Hexan (Hx), dichloromethane (DCM), ethyl acetate (EtAc) and ethanol (EtOH) in term of polarity index was used. The higher unsaturated fatty acid (88.493%) was obtained by Sox with EtAc. Although linoleic acid had higher concentration (36.32%) in mac method. Sox method extracted highest concentration of oleic and linolenic acids (51.99% and 0.385% respectively).
Reza Nassiri Rad; Mohammad Hossein Hadad Khodaparast; Amir Hossein Elhami Rad; Shiva Roufigari Haghighat
Abstract
Green Tea is prepared from the leaves of Camellia sinensis. Catechins of Green tea are well known as natural antioxidants and have effective beneficial on the body. One of the most important processes in the extraction of catechins and producing green tea beverage is brewing process. The object of this ...
Read More
Green Tea is prepared from the leaves of Camellia sinensis. Catechins of Green tea are well known as natural antioxidants and have effective beneficial on the body. One of the most important processes in the extraction of catechins and producing green tea beverage is brewing process. The object of this study is to investigating the effect of brewing temperatures (60٫70 and 80˚c) and duration (5٫10 and 15 min) also the season effect of plucking on green tea that was produced in the Tea Research foundation of lahijan. results of total phenolic content on brewed green tea, is showed that plucking in summer and spring seasons samples have much total phenolic content are rather than plucking in autumn season samples also percent extraction of brewing green tea at 15 minuets has most highest total phenolic content than other seasons and brewing times .brewing temperature are not significant effected on the total phenolic content.
Maryam Azarifar; Mohammad Hossein Hadad Khodaparast; Amir Hossein Elhami Rad; Mohammad Armin
Abstract
In this research, tested factors were margarine types (contractive effects between types of oils in base of margarine such as palm super olein – partially hydrogenated canola oil – 50:50 mixture of palm super olein and partially hydrogenated canola oil and liquid canola) and different moisture ...
Read More
In this research, tested factors were margarine types (contractive effects between types of oils in base of margarine such as palm super olein – partially hydrogenated canola oil – 50:50 mixture of palm super olein and partially hydrogenated canola oil and liquid canola) and different moisture (16-8-4%) as the first factor and heating time is the second factor. Every margarines spend 3 times heating and after every heating time, sample was separated to measure of acidite, color , polar compound . Results indicated that margarines based on palm super olein show better heat stability and liquid canola with high moisture have significant different .in acidite and polar compound percent with another margarines during heating steps. Also time of heating have significant effect in changeable factors.
Maryam Azarifar; Mohammad Hossein Hadad Khodaparast; Amir Hossein Elhami Rad
Abstract
In this research, production possibility and shelf life of frying margarine had analyzed. In order, the test was done in factorial form and totally random method. Tested factors were different kinds of margarine (counteractive effect between type of oil in oil phase (canola) and different moisture (16-8-4%) ...
Read More
In this research, production possibility and shelf life of frying margarine had analyzed. In order, the test was done in factorial form and totally random method. Tested factors were different kinds of margarine (counteractive effect between type of oil in oil phase (canola) and different moisture (16-8-4%) as the first factor and time of keeping margarine as the second factor. In this margarine formula, had not used milk because this product must be stable during heating. the results of analyses chemical properties(peroxide)and microbial properties(Mold and yeasts – Coliform – E.Coli and total count)shows: any margarines, after 14 weeks in room temperature (23°C) and refrigerator temperature (5°C) did not achieved to the unusable situation.
Keywords: Liquid margarine, Canola Oil, Peroxide, Shelf life
Mohammad Hossein Hadad Khodaparast; Mohammad Bagher Habibi Najafi; Amir Hossein Elhami Rad; Nasim Divandari
Abstract
Abstract
In recent years several types of protein rich products derived from sesame seeds or sesame meal such as sesame milk are found in the market and have been attracted consumers both in developed and undeveloped countries mainly due to bearing health benefits. Since Iranian consumers have not yet ...
Read More
Abstract
In recent years several types of protein rich products derived from sesame seeds or sesame meal such as sesame milk are found in the market and have been attracted consumers both in developed and undeveloped countries mainly due to bearing health benefits. Since Iranian consumers have not yet been familiar with such healthy milk analog products, the objective of this study was to introduce the best formulation of sesame milk made from dehulled sesame seeds as well as sesame meal according to Iranian preferences. In order to make a beverage which is almost equal to composition of milk, two main factors were chosen as variable namely pH(6.5, 7.5, 8.5), and time of mixing and extraction (15 to 30 min), the ratio of sesame to water was fixed at 1:6 based on literature and our previous work. The optimum combination of those factors was then determined in a complete randomized design method with a factorial experiment. The selected sesame milk trials from both sesame seeds and sesame meal were then formulated as follow: sugar (0, 5, 6, and 7 %) and vanillin (0, 40, 60, 80 ppm) and all samples were organoleptically judged on the basis of overall acceptability. The collected data were then statistically analyzed using a nine point hedonic method. The results shown that the best sesame milk formulation is the one obtained as follow: the ratio of seed to water (1:6), natural pH (6.5), 15 min mixing time, 6% sugar and 40ppm vanillin.
Key words: sesame milk, sesame seeds, sesame meal.
Amir Hossein Elhami Rad; Ali Asghar Mohammadi
Abstract
In this study Salix aegyptica hydrolat based carbonated drinks were formulated. Differents ratio of Salix aegyptica hydrolat (egyption willow water) mixed with carbonated water, citric acid and sugar to adjust the final drink to 10-12 Brix and desirable acidity. Sensory properties of the products were ...
Read More
In this study Salix aegyptica hydrolat based carbonated drinks were formulated. Differents ratio of Salix aegyptica hydrolat (egyption willow water) mixed with carbonated water, citric acid and sugar to adjust the final drink to 10-12 Brix and desirable acidity. Sensory properties of the products were evaluated at a ranking test by a trained panelists for choosing the best formulation. Evaluation of the product shelf life, samples were stored at different conditions during 6 months and their physicochemical and microbial properties were determined bimonthly. The product factors were evaluated in this study included: acidity, pH, total soluble solids (TSS), turbidity, fungal growth and total count of aerobic and mesophilic microorganisms .The results showed that pH, acidity and TSS had no considerable change, but turbidity increased during storage. Turbidity of samples that stored in presence of light and ambient temperature were increased considerably. Microbiological evaluations showed that total count of aerobic and mesophilic microorganisms was higher in samples that stored at ambient temperature and transparent bottles.On the basis of the results obtained from sensory evaluations at the end of storage time, it was indicated that all different stored trails were as good as the fresh sample.
Key words : Salix aegyptica , Carbonated drink, Medicinal plants
Amir Hossein Elhami Rad; Fakhri Shahidi
Abstract
Bulk tomato paste which is produced by most domestic factories in cocentrations more than 35% (35-40 degree of brix), and filled in to barels as bulk quantity under non - hermetic conditions.The microbial contamination level in this product is high since there is no any post heat treatment. for sterilization ...
Read More
Bulk tomato paste which is produced by most domestic factories in cocentrations more than 35% (35-40 degree of brix), and filled in to barels as bulk quantity under non - hermetic conditions.The microbial contamination level in this product is high since there is no any post heat treatment. for sterilization and microbial redaction Barels maybe stored at coldstore or ambient temperatures for more than 8 months. With limiting of raw material (tomato fruits) in winter ,bulk tomato paste is reconstituted and filled in cans as or commertial conservation. On the basis of the results obtained from the evaluation of fungal contaminations in bulk tomato paste in cold store ,it was determined that the main fungal flora of this product is contained different species of two genera Aspergillus and Penicillium.These moulds grow easily in temperatures near 0ْ C and influence the qualitative properties of the product. It was found that using high brix (≈38 ) in production of tomato paste and storing in 0ْc had only limiting effect on the fungal growth and could not prevent it completely.
